2010 Toyota RAV4 Rear recall 16V596000
Safety recall
Symptoms / what can happen
Failure of the rear tie rod could cause a loss of vehicle control, increasing the risk of a crash.
Cause
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2006-2011 Toyota RAV4 vehicles manufactured October 31, 2005, to September 7, 2010, and 2010 Lexus HS250h vehicles manufactured July 6, 2009, to August 26, 2010. The affected vehicles have rear suspension arms (rear tie rods) with adjusting lock nuts that may have been improperly tightened after servicing. As a result of being loose, the arm may have thread damage and may rust, possibly leading to the failure of the arm and an abrupt change in the vehicle's alignment.
The fix, in plain English
Safety recall work is done free by a franchised dealer. Official remedy: Toyota will notify owners and dealers will replace both rear suspension arms and encapsulate the locknuts, free of charge. The recall began on September 30, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are G0V for Toyota vehicles and GLK for Lexus vehicles. Note: This recall supersedes recall 13V-383, in which some vehicles were only inspected, sealed, and did not have both arms replaced. The affected vehicles were previously recalled under 13V-383, but did not have both rear suspension arms replaced at that time. Those vehicles need to have both arms replaced as part of this recall remedy.
Difficulty
Not DIY: recall remedies are performed by a franchised dealer.
Cost
Free to the owner at a dealer while the recall applies. Outside the recall, costs vary; get a written quote.
Typical parts (search links, no affiliate codes)
AutoZone · O'Reilly · Advance · RockAuto